Effect of rearing system and mixing at loading on transport and lairage behaviour and meat quality: comparison of outdoor and conventionally raised pigs

The effect of raising pigs outdoors or conventionally in a barren environment was investigated with respect to behaviour during a 3 to 4 h journey and a 2 h lairage, blood chemistry at slaughter and meat quality characteristics. Pigs were either kept in farm pen groups or were mixed at loading and kept in the groups, so formed, until slaughter. Non-mixed outdoor pigs settled more quickly during transport and lay down to a greater extent at the end of the journey and lairage period compared with conventionally raised pigs. Mixing led to fewer pigs sitting and lying during transport for conventionally raised pigs, where nearly 80% were still standing at the end of the journey. Mixing had no effect on pig posture in the lairage. Outdoor pigs were less aggressive than conventionally raised pigs especially during lairage and had a lower frequency of unacceptable skin damage in the rear and shoulder area. Aggressive interactions were almost exclusively confined to mixed groups and occurred mainly between pigs from different farm pens, i.e. between unfamiliar animals. Mixing at loading led therefore to higher levels of unacceptable skin damage. Cortisol concentrations in slaughter blood were not affected by rearing system or mixing, but mixed, conventionally raised pigs had higher plasma creatine kinase (CK) activities than non-mixed ones (1132 v. 761 U/l, respectively, P,0.05). Outdoor pigs had similar CK activities, irrespective of mixing (682 and 771 U/l for mixed and non-mixed, respectively). Muscle pH early post mortem was highest in outdoor pigs and muscle temperature lower, but no pig showed pH values below 6.0. Ultimate pH values were both higher (Semimembranosus (S)) and lower (Semispinalis capitis (SC)) than in conventionally raised pigs, and outdoor pigs tended to have a lower frequency of higher than normal pH values. Internal reflectance (MQM) values in Biceps femoris (BF) were highest in outdoor pigs but the incidence of pale, soft and exudative (PSE) meat was low, varying between 0% and 1% for experimental groups. In general, the effects of rearing system and mixing on meat quality measurements taken early post mortem or the day after slaughter were slight, but the trends seen support the CK results, and show that conventionally raised pigs may have found mixing pre-slaughter to be more physically stressful than outdoor pigs did.